Air Duct Repair in Renton - Tested First, Written Price Second

Trusted Air Duct Repair for Renton Homeowners

Air duct repair in Renton typically costs $180 to $850 depending on whether we’re sealing a few joints, reconnecting a damaged run, or replacing a section of ductwork. The work covers the problems you can’t easily see: disconnected flex runs in a crawlspace, crushed sections under a floor, and seams that leak heated air into the attic instead of into your living room. Our technicians have up to 12 years of experience, and they carry the same professional-grade Rotobrush and Nikro systems we use on cleaning jobs, so repair and cleaning can happen in one visit. Same-day service is often available. Call (866) 942-6902 and we’ll get you on the schedule.

Call (866) 942-6902

HVAC Duct Installation

HVAC duct installation is the work of putting a new duct system into a home that doesn’t have one, or replacing a layout that was never designed to carry modern airflow. In Renton, we usually see it during additions, conversions of a crawlspace or garage into living space, and older homes where the original ducts fed one furnace and can’t handle a heat pump’s different static pressure. Duct Cleaning Renton brings the full setup for this: Rotobrush rotary agitation, Nikro HEPA capture, and Abatement Technologies air scrubbers running on-site so the dust a new install kicks up stays out of your living areas. Typical cost for a partial installation runs $900 to $3,200; a full-system installation is quoted up front from a written estimate. See our duct cleaning Renton service for what happens after the new layout is in.

When a New Layout Makes Sense

A new layout makes sense when the current ducts were sized for equipment you no longer have, or when an added room has never had a proper supply and return. It also fits when a room stays hot in summer and cold in winter no matter what you do at the thermostat. Reinstalling from scratch often costs less than chasing leaks one at a time.

Sizing and Static Pressure Checks Before We Cut

We measure the system before any ductwork goes in, because a duct that’s too small for the blower wastes energy and can wear out your equipment. Our technicians read static pressure and check the equipment’s rated airflow so the layout matches what your furnace or heat pump actually moves. It’s a check most installers skip and every homeowner pays for later.

Air Duct Replacement

Air duct replacement means pulling out a duct system that has reached the end of its useful life and installing new material in its place. You need it when the ducts are collapsing, saturated with moisture, or wrapped in insulation that has deteriorated past the point where patching holds. In Renton, a lot of this comes from older flex duct that was never installed with proper support and sags under its own weight. Duct Cleaning Renton replaces the affected runs and confirms the rest of the system is sound before we recommend a full swap. Typical air duct replacement runs $1,400 to $4,500 for most single-family homes, with the final figure set by the written estimate. Our Renton page covers the wider picture of how our service works here.

Repair Versus Replace

Repair wins when the damage is localized: one crushed run, a couple of disconnected joints, or a section chewed through by rodents. Replace wins when the duct material itself is failing, because patching a deteriorating system just moves the problem down the line. A free on-site estimate tells you which side of that line your home sits on.

What Gets Replaced and What Stays

The trunk line often survives; the branch runs to individual rooms usually don’t. We scope the replacement around what’s actually failing and leave sound sections alone. You get a written scope and price before we touch anything.

Ductwork Repair

Ductwork Repair is the targeted fix: sealing leaks, reconnecting separated sections, re-supporting sagging runs, and sealing around registers where air escapes into the wall cavity. You need it when rooms don’t heat evenly, when you hear whistling or rattling at high fan speed, or when the dust in your home keeps coming back no matter how often you clean. Duct Cleaning Renton inspects with a camera through the system, then repairs the sections that are actually failing rather than quoting a full replacement. Most ductwork repair in Renton runs $180 to $650 per area, with the written estimate setting the final price. Newer homes near the Highlands tend to have flex duct that needs re-support more than replacement. Check our service in East Renton Highlands if that describes your property.

Finding Leaks You Can’t See

Most duct leaks are inside a closed cavity or above a conditioned ceiling, which is why a homeowner never spots them until the energy bill jumps. We use a camera run through the system and pressure readings at the registers to locate where the air is going. A leak you can feel at a register is often the small one; the big leaks hide behind drywall.

Sealing Materials We Use

We use mastic and foil-backed tape on metal, and proper mechanical fasteners plus mastic on flex duct. Standard gray “duct tape” is not duct-appropriate and rarely holds past a season of temperature swings. If your ducts are already taped with it, that’s a repair waiting to happen.

Duct Replacement

Duct Replacement is the full step: taking out an old duct system and putting in new, correctly sized ducts tied to your existing equipment. It’s the right call when the old system is undersized for the equipment, when rodents have left the interior contaminated, or when the ducts have been crushed flat in a crawlspace and can’t be restored. Duct Cleaning Renton handles the whole replacement, from the camera inspection before the quote to the airflow test after. Duct replacement in Renton generally runs $1,400 to $4,500 depending on how many runs are involved and whether the attic or crawlspace access complicates the work. The written estimate sets the number, and nothing is added once we start.

Why Undersized Ducts Are a Real Problem

An undersized duct forces the blower to work harder and delivers less air than the equipment was rated for. That’s how you end up with a heat pump that runs longer than it should and rooms that never quite reach the set temperature. Replacing with correct sizing is often the fix that makes the whole system feel new again.

Rodent Contamination and When to Replace

If rodents have been inside the duct system, the interior lining is usually compromised even after a cleaning. Replacement is often the only honest answer in that case, especially if you or anyone in the home has allergies. We’ll show you the camera footage before recommending it, so you can make the call with the same information we have.

Ductwork Installation

Ductwork Installation covers adding new duct runs to an existing system: a supply and return to a converted garage, a new branch to an addition, or a whole new zone off an existing furnace. You need it any time you add liveable space that the original duct design never accounted for, or when a room gets no airflow because no duct reaches it. Duct Cleaning Renton plans those runs around the equipment’s actual capacity, not around what’s easy to route through the ceiling. Ductwork installation in Renton typically runs $450 to $1,800 per new run, with multi-run additions quoted as a package on the written estimate. Newcastle homes we work on often face the same conversion jobs we do here.

Planning a Duct Run for an Addition

Adding a run starts with confirming the blower can carry the extra airflow without starving the existing rooms. We measure static pressure before and after so the new room gets its share without leaving the rest of the house short. That check is the difference between an addition that’s comfortable and one that quietly steals from every other room.

Returns Matter as Much as Supplies

A common installation mistake is adding a supply to a new room with no return path, which pressurizes that room and pushes air out through gaps in the walls. We size the return with the supply so the airflow balances end to end. That’s the part of the job most homeowners never think about and the one that determines how it actually feels.

Brands We Service

We work with Honeywell and Aprilaire whole-home air quality systems, which means our technicians understand how those controls, humidifiers, and filtration components tie into your ductwork. That matters when a duct repair involves cutting into a system with a bypass humidifier or a media cabinet installed in the return: the repair has to leave the air quality equipment functioning correctly. We also use Rotobrush and Nikro equipment because both are purpose-built for duct work, not repurposed shop vacs. A Guardsman-style airflow test is part of how we verify the repair actually delivered.

Whether you’re running Honeywell, Aprilaire, or any other make, we can help. Newcastle and Renton homes keep coming back to the same three issues: crushed flex, disconnected joints, and undersized runs. Knowing the brand of the air quality equipment tells us how to handle the duct without affecting its controls. Whether you have Honeywell or any other make, we can help.

Signs You Need a Pro Right Now

• Rooms that never heat or cool evenly. If one room runs five degrees off the rest, the duct feeding it is likely crushed or disconnected. This is the most common repair we see in Renton homes.
• Whistling or rattling at the registers. Whistling usually points to a duct that’s been pinched or reduced from its original size. Rattling often means a duct has come loose from its hanger.
• Dust that returns within a week of cleaning. If the dust in your home comes back fast, the ducts are leaking from the attic or crawlspace into the living space. Cleaning without repairing that connection is a waste of money.
• Higher energy bills with no change in habits. Leaking ducts spill heated or cooled air into spaces you don’t live in. The bill shows up before the leak does.
• Visible damage in the crawlspace or attic. Crushed flex, torn insulation, and rodent damage are easy to spot if you look. If you find any, stop using the system until a technician inspects it.

Our Process, Step by Step

1. 1
   Phone consultation. We ask what you’re seeing and hearing, then book a visit for the next available opening. Call (866) 942-6902. We answer 24/7. Fast dispatch from 7am to 7pm, Sunday through Friday.
2. 2
   On-site inspection. A technician runs a camera through the system and reads static pressure at the registers to find where the air is going. You see what we see.
3. 3
   Written estimate. We give you a flat price per system for the repair, agreed before any work begins. No per-vent pricing, no add-ons after the fact.
4. 4
   Containment and repair. Abatement Technologies air scrubbers run on-site to keep dislodged dust out of your living space. Rotobrush and Nikro equipment handle the mechanical work.
5. 5
   Before-and-after documentation and airflow verification. We show you photos of the repair from inside the ducts, then re-read airflow at the registers to confirm the fix worked.

How Much Does Air Duct Repair Cost in Renton?

Our Service Area Near Renton

We serve homeowners in Renton, Newcastle, East Renton Highlands, Boulevard Park, Mercer Island, Burien, White Center, Issaquah, Hobart, and Medina. Dispatch is scheduled Sunday through Friday, 7am to 7pm, and most calls are booked into the next opening. Homes closer to Renton usually get the earliest slots, and we’ll confirm timing when you call. We answer 24/7 at (866) 942-6902.

Frequently Asked Questions About Air Duct Repair in Renton

Schedule Your Air Duct Repair Service in Renton Today

If your ducts are leaking, crushed, or disconnected, the sooner we look the less you’ll spend. Call (866) 942-6902 for a free estimate. We answer 24/7. Fast dispatch from 7am to 7pm, Sunday through Friday. You’ll get a flat price per system agreed before any work starts, before-and-after photos from inside your own ducts, and a written scope you can hold us to.

Written by the team at Duct Cleaning Renton.